Read: 1778

Copy page link
Share link to: Facebook | Twitter

---

Machinery news
6 ways to properly operate a loader.
One light: When the loader is working, the heel is pressed against the floor of the cab, the foot plate and the accelerator pedal are kept parallel, and the gas pedal is gently pressed down.

Second stability: When the loader is working, the accelerator should always be steady. Under normal operating conditions, the throttle opening should be around 70%.

Three separations: When the loader is working, the foot plate should be separated from the brake pedal and placed flat on the floor of the cab, and must not be stepped on the brake pedal. Loaders often work on uneven construction sites. If the foot is always on the brake pedal, the body will move up and down, which will cause the driver to step on the brake pedal carelessly. Under normal circumstances, use the method of controlling the throttle to decelerate to control the engine condition and shift. This not only avoids the overheating of the braking system caused by frequent braking, but also brings convenience to the quick acceleration of the loader.

Four diligence: When the loader is working, especially when the shovel is working, the bucket should be full of materials by cyclically pulling the lifting and bucket joysticks under the condition of stable throttle. The cyclic pulling of the hoisting and bucket levers is what is called "Qin". This process is very important and has a large impact on fuel consumption.

Five coordination: Coordination is the organic cooperation of the lifting and bucket levers. The general digging process of a loader starts by laying the bucket flat on the ground and driving it smoothly toward the stockpile. When the bucket encounters resistance in parallel shoveling to the material pile, the principle of lifting the arm first and then closing the bucket should be followed first. This can effectively avoid resistance at the bottom of the bucket, so that the maximum breakout force can be fully exerted.

Six prohibitions: First, it is strictly forbidden for tires to skid. When the loader is operating, the tires tend to skid when the accelerator is slammed against the resistance. This phenomenon is usually caused by improper operation of the driver, which not only increases the fuel consumption but also damages the tires. Secondly, it is strictly forbidden to tilt the rear wheel. Due to the large breakout force of the loader, the driver is usually in the process of shovelling solid raw soil and stone mountains. If the operation is improper, the two rear wheels are prone to lift off the ground. The landing inertia of this lifting action will cause the blade of the bucket to break and the bucket to deform; when the rear wheel is lifted very high, it is easy to cause cracks in the welds of the front and rear frames, and even the plate breaks. Third, it is strictly forbidden to hit the stockpile. When shovelling common materials, the loader can operate in gear II, and it is strictly forbidden to carry out inertial impact on the stock pile at gears above II. The correct method should be when the bucket is close to the material pile, timely switch the gear to I gear to complete a shoveling process.

---

* Please enter your message in the box below:
Dear sir, I am inquiring about news 6 ways to properly operate a loader

(* denotes a mandatory field)

Title: *

Please Select Mr Miss Mrs Ms Dr Rev Prof

Name: *

Company: *

Country: *

Austria Albania Andorra Australia Armenia Azerbaijan Antigua and Barbuda Anguilla Angola Afganistan Argentina American Samoa Aruba Algeria Belgium Bosnia-Herzegovina Belarus Barbados Banglades Burkina Faso Bulgaria Bahrain Burundi Brazil Benin Bermuda Brunei Darussalam Bolivia Bahamas Buthan Bouvet Island Botswana Belize Canada Croatia Czech Republic China Cocos Islands Central African Republic Congo Chile Cameroon Cook Islands Colombia South Africa Costa Rica Cuba Cambodia Cape Verde Comoros Christmas Island Cyprus Cayman Islands Chad Denmark Djibouti Dominica Dominican Republic Estonia Ecuador Egypt Ethiopia El Salvador East Timor France Finland Fiji Falkland Islands Faroe Islands France (European Territory) Germany Greece Gabon Georgia Grenada Ghana Gibraltar Greenland Guadeloupe Equatorial Guinea Guyana Gambia Guinea Guatemala Guam Guinea Bissau Hungary Hong Kong Heard and McDonald Islands Honduras Haiti Italy Ireland Iceland Indonesia Israel India Indian British Ocean Territory Iraq Iran Ivory Coast Japan Jamaica Jordan Kazachstan Kyrgyzstan Kenya Kiribati Kuwait Saint Kitts Nevis Anguilla North Korea Latvia Lithuania Liberia Lesotho Luxembourg Libya Laos Lebanon Liechtenstein Macedonia Morocco Moldova Monaco Madagascar Marshall Islands Mali Myanmar Macau Northern Mariana Islands Martinique Mauritania Montserrat Malta Mauritius Maldives Malawi Mexico Malaysia Mozambique Mongolia Micronesia Netherlands Norway Netherland Antilles Namibia New Caledonia Niger Norfolk Island Nigeria Nicaragua New Zealand Nepal Nauru Niue Oman Portugal Poland Romania Pitcairn Puerto Rico Palau Paraguay Panama Peru Polynesia Papua New Philippines Pakistan Qatar Russia Reunion Rwanda Spain Slovak Republic Sweden Switzerland South Korea Saint Lucia Sri Lanka Samoa Saint Pierre and Miquelon Saudi Arabia Solomon Islands Seychelles Sudan Singapore Saint Helena Saint Helena Svalbard and Jan Mayen Islands Sierra Leone San Marino Senegal Somalia Suriname Saint Tome and Principe Saint Vincent and Grenadines Syria Swaziland Turkey Turkmenistan Togo Thailand Tokelau Tunisia Tonga Trinidad and Tobago Tuvalu Taiwan Tanzania Turks and Caicos Islands United Kingdom United States United Arab Emirates Ukraine Uganda Uzbekistan US Minor Outlying Islands Uruguay Venezuela Virgin Islands (British) Virgin Islands (UK) Vietnam Vanuatu Vatican City State Wallis and Futuna Islands Western Sahara Yemen Zambia Zaire Zimbabwe

City*:

Phone
(WhatsApp)Number:

E-Mail: *

Please write the result *